What's Covered
The following is a list of what the warranty covers. Please note that this is not a full list of coverage and is subject to change at any time. This page is for information only and nothing contained in this page constitutes part of any warranty agreement or warranty contract.
2 Stroke & 4 Stroke outboard engines
Engine
All internal lubricated parts including: pistons, piston rings and pins, crankshaft and main bearings, rod bearings, timing chain, timing gears, rocker arms, cover, valves, valve springs, guides and seats, valve pushrods, lifters, camshaft and bearings, cylinder heads, cylinder barrels, intake manifold, exhaust manifold, reed and reed blocks, seals and gaskets
Lower Units
All internally lubricated parts contained within the lower gear case and upper gear case housing, reverse gear, pinion gear and shift shaft, housing and case, upper drive gear set, clutch dogs, or cones, shift cams, bearings, shims, bearing carriers, upper drive shaft, prop shaft, forward gear, intermediate or adapter housing, upper steering bearing and gimbal, tilt bearings and lower steering bearings, shaft bell crank, bushing and plug, seals and gaskets
Shaft Drive
Bearings and couplings
Electrical
Alternator, stator, starter, power tilt motor, voltage regulator, regulator rectifier, engine wiring harness, engine terminal blocks, choke solenoid, starter drive, ignition coil, starter solenoid, switch box, ignition module, trigger.
Lubricating System
Oil injection pump, drive gear and/or shaft, oil tank, oil cap, oil level sensor, warning horn, oil lines, complete oil injection metering system, oil injection check valves, seals and gaskets.
Steering
Steering control helm assembly, control rack and pinion and yoke assembly, power steering pump, hydraulic steering head, hydraulic steering lines and control valves, power cylinder assembly, steering wheel and coupling, steering cable, seals and gaskets
Controls
Shift and throttle control cables, ignition switch, neutral start switch, throttle cam lever. Electronic Shift and Throttle controls including ECU's and Actuators
Power Trim and Tilt
Spring sending unit, oil pump, pump relief valve, spring, o-ring, trim cylinder, motor, solenoids, wiring harness, manual release valve, hydraulic pump, reverse lock valve, limit switches, master switches, seals and gaskets.
Fuel System
Fuel distributors, fuel injection pump, fuel injectors, control unit, flame arrestor, fuel pump, carburettor body, diaphragm, Electronic Fuel Injector Coverage Fuel injectors, electronic control modules, throttle position sensor, idle speed solenoid, detonation, knock sensor, ignition control sensor, mass air flow sensor, manifold absolute pressure sensor, crank position sensor, air temperature sensor, coolant sensor, injector wiring harness, fuel injection lines and fittings, all electronic injection sensors and controls.
Inboard Engines (Pod, Stern, Shaft, Jet & V-Drive)
Engine
All internal lubricated parts including: pistons, piston rings and pins, crankshaft and main bearings, rod bearings, timing chain, timing gears, rocker arms, cover, valves, valve springs, guides and seats, valve pushrods, lifters, camshaft and bearings, cylinder heads, cylinder barrels, intake manifold, exhaust manifold, flywheel and ring gear, harmonic balancer, oil pan, oil pump, engine mounts, distributor housing, shaft and bearings, oil cooler housing, oil filter housing, turbocharger housing and all internal parts, turbocharger waste gate actuator, seals and gaskets.
Diesel Engine
All parts included in the engine section including head bolts, air intake housing, flywheel housing and front covers.
Lubricating System
Oil injection pump, drive gear and/or shaft, oil tank, oil cap, oil level sensor, warning horn, oil lines, complete oil injection metering system, oil injection check valves, seals and gaskets.
Cooling System
Engine water pump (excluding outboard impellers), coolant circulating pump, heat exchangers, seals and gaskets.
Fuel System
Fuel distributors, fuel injection pump, electronic fuel injector, control unit, flame arrestor, fuel pump, carburettor body, diaphragm.
Transmission
All internally lubricated parts within the transmission case, transmission mounts, oil pan, gears, bearings, bearing carriers, clutch and thrust plates, clutch drums, shift bands, hydraulic pumps, valve bodies, seals and gaskets.
Shaft Drive
Bearings and couplings.
V-Drive
All internally lubricated parts within the V-Drive case, case, bevel gears, bearings, thrust bearings, shafts, shims and bearing carriers, seals and gaskets.
Jet-Drive
All internally lubricated parts in the pump housing, housing, seals and gaskets.
Pod and Stern Drive/Upper and Lower Units
All internally lubricated parts contained within the gear case and upper housing.
Steering
Steering control helm assembly, control rack and pinion and yoke assembly, power steering pump, hydraulic steering head, hydraulic steering lines and control valves, power cylinder assembly, steering wheel and coupling, steering cable, seals and gaskets.
Controls
Shift and throttle control cables, ignition switch, neutral start switch, throttle cam lever, Electronic Shift and Throttle controls including ECU's and Actuators.
Electrical
Alternator, stator, starter, power tilt motor, voltage regulator, regulator rectifier, engine wiring harness, engine terminal blocks, choke solenoid, starter drive, ignition coil, starter solenoid, switch box, ignition module, trigger.
Power Trim and Tilt
Spring sending unit, oil pump, pump relief valve, spring, o-ring, trim cylinder, motor, solenoids, wiring harness, manual release valve, hydraulic pump, reverse lock valve, limit switches, master switches, seals and gaskets.
Electronic Fuel Injector Coverage
Fuel injectors, electronic control modules, throttle position sensor, idle speed solenoid, detonation, knock sensor, ignition control sensor, mass air flow sensor, manifold absolute pressure sensor, crank position sensor, air temperature sensor, coolant sensor, injector wiring harness, fuel injection lines and fittings, all electronic injection sensors and controls.